CORRECT CRAFT Air Nautique Specifications Page 79
- Page / 100
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
8.21
Engine Troubleshooting
IMPORTANT: The following chart is a guide to aid you find and correct
minor engine malfunctions. If the problem has not been corrected after
following this guide, NO NOT attempt further repairs. See your Correct Craft
dealer.
W
ARNING: Before attempting any checks or repairs, the battery cables
MUST BE REMOVED from the battery to prevent possible personal injury
and damage to equipment.
Trouble: Starter will not turn over.
Put control lever into the neutral position (straight up)
Clean and tighten the cables on the battery
Check electrolyte level in battery
Attach emergency cut-off lanyard to switch and yourself
Trouble: Engine will not start or is hard to start
Add fuel to the tank
Inspect fuel filter for a clog. Replace if necessary
Engine may be flooded. See flooded engine instructions in chpt 2
Inspect spark plugs: clean / gap or replace
Inspect distributor. Clean / replace
Check all electrical wires for wear or solid connection
Emergency cut-off switch not connected
Fuel tank vent clogged. Return the boat to dealer for service
Trouble: Poor engine idling or misses when idling
Check spark plug wires for corrosion
Inspect plugs: clean / gap or replace
Check electrolyte level in battery
Inspect distributor. Clean / replace
Fuel tank vent clogged. Return the boat to dealer for service
Inspect fuel filter for a clog. Replace if necessary
Sport-Air2002.qxd 8/21/01 9:09 AM Page 8.21
8.21
Engine Troubleshooting
IMPORTANT: The following chart is a guide to aid you find and correct
minor engine malfunctions. If the problem has not been corrected after
following this guide, NO NOT attempt further repairs. See your Correct Craft
dealer.
W
ARNING: Before attempting any checks or repairs, the battery cables
MUST BE REMOVED from the battery to prevent possible personal injury
and damage to equipment.
Trouble: Starter will not turn over.
Put control lever into the neutral position (straight up)
Clean and tighten the cables on the battery
Check electrolyte level in battery
Attach emergency cut-off lanyard to switch and yourself
Trouble: Engine will not start or is hard to start
Add fuel to the tank
Inspect fuel filter for a clog. Replace if necessary
Engine may be flooded. See flooded engine instructions in chpt 2
Inspect spark plugs: clean / gap or replace
Inspect distributor. Clean / replace
Check all electrical wires for wear or solid connection
Emergency cut-off switch not connected
Fuel tank vent clogged. Return the boat to dealer for service
Trouble: Poor engine idling or misses when idling
Check spark plug wires for corrosion
Inspect plugs: clean / gap or replace
Check electrolyte level in battery
Inspect distributor. Clean / replace
Fuel tank vent clogged. Return the boat to dealer for service
Inspect fuel filter for a clog. Replace if necessary
Sport-Air2002.qxd 8/21/01 9:09 AM Page 8.21
- Dear Correct Craft Owner: 1
- ABLE OF C ONTENTS 2
- Chapter 1 5
- Keyless Ignition 6
- Bilge pumps 10
- PME Bypass 11
- Throttle 13
- Lifting Rings 14
- Capacity Plate 15
- Drivers Seat Adjustment 16
- Manual Latch Release 18
- Launch Control Seacocks 18
- Flight Clips 19
- Chapter 2 25
- Flooded engine 27
- Break In Procedure 28
- G ENERAL NOTES 28
- Chapter 3 31
- Fuel Control Cell 35
- Side Console 36
- Flight Control Tower 37
- Chapter 4 39
- Chapter 5 41
- PROPELLER SHAFT STUFFING BOX 44
- Through-Hull Fittings 45
- Oil Drain System 45
- Salt Water Boating 46
- Battery Maintenance 46
- Winterizing Your Boat 47
- Gelcoat Care 48
- TUNABLE RUDDER 51
- Chapter 6 53
- Long Trips 54
- Chapter 7 55
- Chapter 8 59
- Service For Your PCM Engine 60
- Raw Water Strainer 63
- Transmission Cooler 63
- Principals of Operations 67
- PECIFICATIONS 68
- Fresh Water Cooling 70
- Checking Coolant Level 71
- Flushing Instruction 75
- Cylinder Number Locations 76
- Engine Troubleshooting 79
- PCM Chevrolet 350/5.7 81
- PCM Ford GT-40 82
- PCM Chevrolet Python 83
- PCM Chevrolet 305/5.0 84
- Wire colors 86
- Chapter 9 89
- Warranty Transfer 91
- PRE DELIVERY CHECK LIST 92
- NAUTIQUE FRIEND PROGRAM 93
- OF CORRECT CRAFT, INC. BOATS 97
- Glossary 99
- Revised 7/27/2001 100
Related products and manuals for Motor vehicle accessories & components CORRECT CRAFT Air Nautique
(98 pages)© 2020, manymanuals.com. All rights reserved. | 0.981 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals